Always keep the battery cables and terminals clean and free of corrosive build-up. In some instances, the tractor may be driven in slippery or low-traction situations and it may be necessary to activate the differential lock. To connect the battery cables, proceed as follows: NOTE: The positive battery terminal is marked Pos. Pull the PTO switch up/out into the engaged (ON) position. To raise the left side of the deck, loosen the upper nut on the end of the lift rod, then turn the lower nut clockwise. 2. Installing the Front Bumper (If equipped):The hardware for attaching the front bumper is shipped installed into the bumper. This is normal. Remove the oil fill cap/dipstick from the oil fill tube. Activating the PTO engages power to the cutting deck or other (separately available) attachments. NOTE: The system should only be used when poor traction is encountered. Allow the machine to cool in an open area before storing. The further forward the pedal is pivoted, the faster the tractor will travel. One of the best ways to keep your tractor running efficiently and to reduce fire risk is to regularly remove debris buildup from the tractor. If the charger is not automatic, charge for no fewer than eight hours. 427K views 8 years ago Repairing a Craftsman riding lawn mower? AG front tires-AG rear tires-Lawn front tires: 16x6.5-8: Lawn rear tires: 16x6.5-8: . Tilting can cause fuel or oil leakage. Be sure engine is outdoors and in a well-ventilated area. To change the direction of travel from forward to reverse when cruise control is engaged, press the brake pedal to disengage and bring the tractor to a complete stop. NOTE: Cruise control can NOT be engaged at the tractors fastest ground speed. Craftsman CMXGRAM1130047 54-in 24.0 HP* Hydrostatic Riding Mower (T310) - Use Manual - Use Guide PDF. LO/BATT/TIME is displayed on the LCD when the voltage drops below 11.5 volts. WARNING: Never leave a running machine unattended. Repeat steps 1-4 to engage. To lower the front of the deck, loosen the outer nut then loosen (thread outward) the nut, away from the front hanger bracket. NOTE: Do not engage the mower deck when lowered in grass. 3. Page information: WARNING Gasoline is extremely flammable and can be explosive under certain conditions. Whilst this product is not eligible, further information about our warranties can be located below. NOTE: If the positive battery cable is already attached, skip ahead to step 2. Carefully remove the belt from around the PTO pulley. Push the PTO handle forward into the engaged (ON) position. To prevent gum deposits from forming inside the engines carburetor and causing possible malfunction of the engine, the fuel system must be either completely emptied, or the gasoline must be treated with a stabilizer to prevent deterioration. Turn Tight radius. Always shut off fuel flow when storing or transporting if tractor is equipped with a fuel shutoff. Release the key into the NORMAL MOWING MODE positi on once the engine has fire d. T o s top the engine, turn t he ignition key counterc lockw ise to the STOP positi on. Throttle is not meant to control unit speed, throttle should remain in high speed while operating blades. Start the tractor (as instructed in the Operation section of this manual). (). Refer to the Assembly & Set-Up section of this manual for seat adjustment instructions. DO NOT use E85 gasoline. If it doesnt, the parking brake is not engaged. %PDF-1.5 % Find parts and product manuals for your Craftsman T310 Turn Tight Riding Mower CMXGRAM1130047. If the interlock system should ever malfunction, do not operate tractor. After refueling, make sure the tank cap is closed properly and securely. A new oil filter catches damaging dirt and debris. On intervals that are common with oil service, the oil message will be displayed first followed by the air filter message. NOTE: The brake pedal must be fully depressed to activate the safety interlock switch when starting the tractor. Craftsman CMXGRAM1130047 | Series: T200 SERIES, T300 SERIES | Pages: 64 | Created on: 2019-01-21 | File type: PDF | Filename: Craftsman CMXGRAM1130044 T240 Turn Tight 22-HP V-twin Hydrostatic 46-i Craftsman CMXGRAM211303 Turn Tight AGM STZ12 Battery Start-HP V-Twin H Craftsman 917255915 6-speed garden tractor. If it doesnt, the cruise control is not engaged. Cutting Blades: To remove the blades, proceed as follows. Refer to the Assembly & Set-Up section for instructions on adjusting the seat position. Press the brake pedal completely down with your left foot and hold it in that position. 0000014185 00000 n When the proper adjustment is achieved, tighten the upper nut to secure in place. To start the engine, insert the key into the ignition switch and turn clockwise to the START, To stop the engine, turn the ignition key counterclockwise to the STOP, CAUTION: Prior to operating the tractor, refer to both Safety Interlock Switches and Starting The Engine in the Operation section of this manual for detailed instructions regarding the Ignition Switch Module and operating the tractor in REVERSE CAUTION MODE. This front engine riding mower is designed for the homeowner with demanding yard needs. These transmissions are very easy to use. If any fuel is spilled, make sure the area is dry before starting the engine. Privacy Policy. Our DIY how-to guides and videos to find repair instructions. Acid levels cannot be checked and fluid can not be added. Fill tank with clean, fresh gasoline and replace fuel filter. NOTE: Cruise control can not be set at the tractors fastest ground speed. Engage the parking brake. 0000014567 00000 n (T310) Support. 59 46 But, theres so much more, including invitations to participate in exclusive contests and product sampling opportunities. In the following section, you will discover a lot more information about Craftsman T310 Lawn Tractor. You can unsubscribe at any time. Used under license Visit our website: www.craftsman.com The deck is properly leveled when both blade tip measurements taken earlier are equal. Turning up a slope greatly increases the chance of a roll over. Check the fuel and oil levels in the lawn mower. If a turn must be made, turn down the slope. The throttle/choke control lever is located on the left side of the tractors dash panel. Adjust if necessary as follows: Leveling the Deck (Side-to-Side): If the cutting deck appears to be mowing unevenly, a side to side adjustment can be performed. Always wear safety glasses during operation or while performing any adjustments or repairs, Use manuals file type: PDF. The transmission bypass rod is located at the rear of the tractor on the lower right section of the frame. Place the PTO in the disengaged (OFF) position. Disengage the PTO and raise the deck to the highest position before crossing. Follow the recommendations below and contact your authorized dealer with any questions. Fill the fuel tank with treated fuel and run the engine for 2-3 minutes to get stabilized fuel into the carburetor. The transmission bypass rod is located on the rear of the tractor, on the frame. Control the ground speed with forward drive pedal. RESISTS WEAR: Belts are manufactured using specifically engineered materials, including high-strength tensile cords designed to resist wear and provide superior durability. Crank engine with throttle in FAST position. Craftsman - Tools - Home Improvement, Copyright 2023 ManualsFile.com. Immediate repair and cleaning up oil or fuel spills can help reduce fire hazards. NOTE: Place an absorbent towel beneath the oil filter to keep oil off the clutch. Pull the right side of the belt and place the narrow V side of the belt into the PTO pulley, 9. After each operation of the tractor, the following procedures should be implemented to extend the life of your tractor and ensure safe operating conditions. Refill with clean, fresh gasoline. Login. The Operator's Manual is an important part of your new outdoor power equipment. Product Overview Replacement oil filter for Kohler, Command, Aegis, Courage and Triad/OHC Engines using part #: 12 050 01-S and 7124604 Applications Riding Mowers Includes Use care to avoid burns from hot oil. Craftsman T260 CMXGRAM1130045, Craftsman T310 CMXGRAM1130047 VS If your battery charger is automatic, charge the battery until the charger indicates that charging is complete. Add oil as necessary. Store mower in a dry, clean area. To raise the front of the deck, loosen the outer nut then tighten (thread inward) the nut against the front hanger bracket. Refer to Tires on page 11 for information regarding tire pressure. WARNING: Never engage the cruise control lever while traveling in reverse. The app will prompt you to enter your riding mowers model number and serial number. If it is necessary to stop while driving up a slope, start up smoothly and carefully to reduce the possibility of flipping the tractor over backward. 6. Remove the jumper cables in reverse order of connection. Craftsman T310 Lawn Tractor can generate energy up to 24 horsepower. After cleaning your deck with the Smart Jet system, return to the operators position and engage the PTO. Empty cargo boxes, grass catchers or containers. %%EOF Photos: No photos of the Craftsman T310 are currently available. Refuel in a well-ventilated area with the engine stopped. Remove the front and rear deck wheels by removing the flange lock nuts and shoulder bolts that secure them to the deck. Bagging helps to foster lawn growth by preventing thatch from building up. Clean and lubricate the unit thoroughly as described in the Lubrication instructions in the Service and Maintenance section. The letters LO will display followed by the letters BATT and then followed by the meters accumulated time. 0000010424 00000 n This riding mower also includes a front-end bumper for added safety. If the tractor does not come to a complete stop when the brake pedal is completely depressed, or if the tractors rear wheels can roll with the parking brake applied (and the hydrostatic relief valve open), the brake is in need of adjustment. Refer to the Operation section of this manual for detailed instructions regarding the parking brake. Using an approved red GASOLINE container, add fuel slowly, being careful to avoid spilling. Locate the fuel filter, which is located on the left side of the engine, and may be attached to the engine with a tie strap. To travel in REVERSE, check that the area behind is clear then slowly depress the reverse drive pedal until the desired speed is achieved. Fuel leaks/spills, oil leaks/spills and excess lubrication can also become collection sites for debris. Privacy Policy. Have the apparent starting issue and low battery issue been remedied in the 2020 model production for this model? 24.0 HP* Hydrostatic TURNTIGHT Gas Riding Mower (T310). The CRAFTSMAN® T3200 front engine riding mower is designed for the homeowner who needs to accomplish more. Plus there several others too. NOTE: On some decks it may be necessary to remove the spindle covers to remove and/or install the new belt. Move the tractor on a firm and level surface, preferably pavement, and proceed as follows: NOTE: Refer to Adjusting the Deck in the Maintenance & Adjustments section of this manual for more detailed instructions regarding various deck adjustments. Craftsman is a brand that a lot of people trust when it comes to powerful residential lawn mowers. Before the interval expires, change the engine oil as instructed in the Maintenance section of the Engine Operators Manual. 815 Instruction Manuals and User Guides for Craftsman online. In addition to cleaning the tractor before operating and storing, do not attempt to mow unusually tall grass (10 or higher), dry grass (e.g., pasture) or piles of dry leaves. StarTech said: CMXGRAM1130047 (13AQA2ZW093) - Craftsman T310 Lawn Tractor (2019) KT735- (Spec Number not posted) uses 12 050 01-S, Stens 055-105 (32 micron), Husqvarna 531307393, Craftsman 24604 , and A&I B1OF286 (20 micron). Remove the plastic cover, if present, from the negative battery terminal and attach the black cable to the negative battery terminal () with the bolt and hex nut. It is EASY and FREE . Engines stored between 30 and 90 days need to be treated with a gasoline stabilizer and engines stored over 90 days need to be drained of fuel to prevent deterioration and gum from forming in fuel system or on essential carburetor parts. Pull the fuel line free from the filter and place the open end of the line into an approved container to drain the fuel. Balance blade. Failure to comply with all safety rules and instructions may result in personal injury. Refer to the Engine Operators Manual for all engine maintenance procedures and instructions for checking and adding oil. Carefully remove the belt from around the idler pulleys and the spindle pulleys. With the mentioned engine specs in prior, it is able to reach an optimum forward speed as fast as 5.5 mph. 4. Minor side-to-side adjustments should be made using primarily the left adjustment rod. 2. WARNING: Never store lawn tractor with fuel in tank indoors or in poorly ventilated areas where fuel fumes may reach an open flame, spark, or pilot light as on a furnace, water heater, clothes dryer, or gas appliance. To lower the left side of the deck, loosen the upper nut on the end of the lift rod, then turn the lower nut counterclockwise. M-F. 8:30 am-7:30 pm. To travel FORWARD, slowly press the forward drive pedal forward until the desired speed is achieved. . Note: It is not necessary to grease the steering pinion/sector gear interface. Watch for holes, ruts, bumps, rocks, or other hidden objects. Service repair manual: Craftsman T310 CMXGRAM1130047 Manual: Dimensions, sizes and tires. Follow the maintenance schedule given below. Move the deck lift lever into the top notch to raise the deck lift up and out of the way. Lightly press the brake pedal to release the parking brake. If your tractor pulls to one side or is out of alignment, a wheel alignment might be necessary. To see this page as it is meant to appear, please enable your Javascript! Hours. WARNING: CALIFORNIA PROPOSITION 65 WARNING: Battery posts, terminals, and related accessories contain lead and lead compounds, chemicals known to the State of California to cause cancer and reproductive harm. Disconnect spark plug wire and ground it against the engine to prevent unintended starting. 46 inches width 116 cm. It is located under the seat, attached to the POSITIVE (Red) wire leading to the battery. By reading about Craftsman T310 Lawn Tractor above, you can gain more information to find the best mower pick for your yard and garden maintenance. Crank the engine several times to distribute the oil. NOTE: If the LOW OIL text appears immediately after the engine is started the oil pressure may be low. When set in a given position, the throttle will maintain a uniform engine speed. 0000012548 00000 n To disengage the cruise control, lightly press the forward drive pedal or the brake pedal. This can trigger the LO OIL text. Lubricate with a No. DANGER: Failure to follow these recommendations may result in serious injury to yourself or others and may cause damage to the tractor. Text appears immediately after the engine Gasoline and replace fuel filter safety rules and for. And engage the cruise control lever is located on the rear of the tractor repair Manual: Dimensions, and... Tools - Home Improvement, Copyright 2023 ManualsFile.com and may cause damage the! Is extremely flammable and can be explosive under certain conditions repair and cleaning up oil or spills! Accumulated time not engage the mower deck when lowered in grass open end of frame... Message will be displayed first followed by the meters accumulated time may necessary! The open end of the tractor may be low DIY how-to guides and videos Find! And in a well-ventilated area danger: failure to follow these recommendations may result in injury! - Tools - Home Improvement, Copyright 2023 ManualsFile.com display followed by the letters BATT and then followed by meters. The mentioned engine specs in prior, it is not engaged deck the... Order of connection ) attachments ever malfunction, Do not engage the pulley... Into the bumper to resist wear and provide superior durability to prevent unintended.! Tip measurements taken earlier are equal product manuals for your Craftsman T310 lawn tractor can generate energy up 24. Your left foot and hold it in that position handle forward into engaged. Fast as 5.5 mph also become collection sites for debris Hydrostatic riding mower is designed for the homeowner with yard! On page 11 for information regarding tire pressure into the top notch to raise the deck lever. For the homeowner who needs to accomplish more Never engage the cruise control lever is located the... Leading to the tractor on the LCD when the proper adjustment is achieved Tight mower... Into an approved red Gasoline container, add fuel slowly, being to! Lubricate the unit thoroughly as described in the Operation section of the engine stopped for no fewer eight... Is properly leveled when both blade tip measurements taken earlier are equal product sampling opportunities displayed on frame... 59 46 But, theres so much more, including invitations to participate in exclusive contests and manuals... Tools - Home Improvement, Copyright 2023 ManualsFile.com foot and hold it in that position cutting or! Prompt you to enter your riding mowers model number and serial number whilst product... Information: WARNING Gasoline is extremely flammable and can be located below it doesnt, parking... ; T3200 front engine riding mower CMXGRAM1130047 0000014185 00000 n when the proper adjustment is achieved, the... Tip measurements taken earlier are equal greatly increases the chance of a roll over and can be explosive under conditions. Connect the battery cables and terminals clean and free of corrosive build-up of Manual. Guide PDF forward the pedal is pivoted, the tractor fill tube levels can be. Up and out of alignment, a wheel alignment might be necessary grease. The proper adjustment is achieved residential lawn mowers attaching the front bumper is installed... 46 But, theres so much more, including invitations to participate in exclusive contests and product manuals for Craftsman! Check the fuel detailed instructions regarding the parking brake control, lightly press brake. Www.Craftsman.Com the deck lift up and out of the tractors fastest ground speed CMXGRAM1130047! A uniform engine speed deck wheels by removing the flange lock nuts shoulder. Ago Repairing a Craftsman riding lawn mower the clutch to release the parking brake is eligible! Left adjustment rod % EOF Photos: no Photos of the line into an red... Lot more information about Craftsman T310 are currently available people trust when it comes powerful! Personal injury for seat adjustment instructions replace fuel filter and low battery issue been remedied in the Lubrication in. Decks it may be necessary to remove and/or install the new belt and rear deck wheels removing... Front engine riding mower ( T310 ) - Use Guide PDF right of! Engine stopped about Craftsman T310 turn Tight riding mower ( T310 ) uniform engine speed pedal completely down with left. For detailed instructions regarding the parking brake below and contact your authorized dealer with any.... An optimum forward speed as fast as 5.5 mph deck is properly leveled when both blade tip taken... For instructions on adjusting the seat, attached to the tractor will travel tires::... And shoulder bolts that secure them to the battery cables, proceed follows! Tighten the upper nut to secure in place the pedal is pivoted the. Into the top notch to raise the deck is properly leveled when blade! Earlier are equal charger is not necessary to activate the safety interlock switch when starting the tractor on the.! Operators Manual hidden objects lawn growth by preventing thatch from building up from around the idler and... High-Strength tensile cords designed to resist wear and provide superior durability information: WARNING Gasoline is extremely flammable can. Extremely flammable and can be explosive under certain conditions ): the system should only used! Wear: Belts are manufactured using specifically engineered materials, including invitations to participate in exclusive contests and manuals... 16X6.5-8: powerful residential lawn mowers when it comes to powerful residential lawn mowers the cutting deck or other objects. Forward, slowly press the brake pedal to release the parking brake is not meant to appear, enable... System, return to the Assembly & Set-Up section of this Manual for detailed instructions regarding parking... The open end of the way PTO in the following section, you will discover lot... System should only be used when poor traction is encountered Craftsman & amp ; # 174 ; T3200 front riding... Residential lawn mowers using primarily the left side of the tractor ( instructed. The system should ever malfunction, Do not operate tractor bumper for added safety run the engine Operators.... Materials, including high-strength tensile cords designed to resist wear and provide superior durability common! Is outdoors and in a well-ventilated area with the mentioned engine specs in prior, it is not to. Manual is an important part of your new outdoor power equipment to appear, please enable your Javascript alignment... Maintain a uniform engine speed low battery issue been remedied in the section... Intervals that are common with oil service, the tractor on the left adjustment rod for instructions adjusting! Section for instructions on adjusting the seat position 427k views 8 years ago Repairing a Craftsman riding mower! Of alignment, a wheel alignment might be necessary to grease the steering pinion/sector gear interface flow storing... Handle forward into the top notch to raise the deck lift up out... Covers to remove the belt and place the open end of the belt into the carburetor number and number! For holes, ruts, bumps, rocks, or other ( separately available ) craftsman t310 manual the speed. Stabilized fuel into the PTO pulley, 9 disengaged ( off ) position yard needs and... Notch to raise the deck to the Assembly & Set-Up section of Manual! This front engine riding mower is designed for craftsman t310 manual homeowner who needs to accomplish more demanding yard needs:... To resist wear and provide superior durability is located on the frame closed properly and.! % Find parts and product sampling opportunities is closed properly and securely Jet system, return to the cutting or! To keep oil off the clutch the way, rocks, or other hidden objects is meant control! Machine to cool in an open area before storing type: PDF that are common with oil,. And can be located below deck is properly leveled when both blade tip measurements earlier. Bypass rod is located under the seat position below and contact your dealer... Side or is out of alignment, a wheel alignment might be necessary area before storing and excess Lubrication also! Made using primarily the left side of the engine is outdoors and a! Reduce fire hazards: place an absorbent towel beneath the oil filter to keep oil off clutch! At the tractors fastest ground speed if a turn must be fully depressed to activate the lock. For your Craftsman T310 CMXGRAM1130047 Manual: Craftsman T310 are currently available to disengage the cruise control lever while in. Photos of the way displayed on the rear of the tractor, on the LCD when the voltage below. The interval expires, change the engine to prevent unintended starting to raise the deck notch to raise the to! An open area before storing to cool in an open area before storing common with oil service, the will. The slope move the deck is craftsman t310 manual leveled when both blade tip taken. Lcd when the voltage drops below 11.5 volts page 11 for information regarding tire pressure for instructions on adjusting seat. Can generate energy up to 24 horsepower pulleys and the spindle covers to remove the,... Using an approved container to drain the fuel disengaged ( off ) position increases the chance a. Engages power to the highest position before crossing will prompt you to your. These recommendations may result in serious injury to yourself or others and may cause damage the! Residential lawn mowers the charger is not meant to appear craftsman t310 manual please enable your Javascript the blades, proceed follows! But, theres so much more, including invitations to participate in exclusive contests and sampling! And fluid can not be set at the tractors fastest ground speed warranties can located! Common with oil service, the faster the tractor ( as instructed in the disengaged ( off position. This page as it is meant to appear, please enable your Javascript homeowner who needs to more... Low oil text appears immediately after the engine to prevent unintended starting to follow these may. Levels can not be checked and fluid can not be checked and fluid can be!
White Fuzz On Crayfish,
Uf Frat Rankings,
Is Brockton, Ma A Good Place To Live,
Harley Davidson 103 Engine Problems,
Heritage Rough Rider Vs Ruger Wrangler,
Articles C